User manual YAMAHA TT-R110E

[. . . ] Read this manual carefully before operating this vehicle. OWNER'S MANUAL TT-R110EY LIT-11626-22-53 5B6-28199-11 EAU10042 Read this manual carefully before operating this vehicle. This manual should stay with this vehicle if it is sold. INTRODUCTION EAU41733 Congratulations on your purchase of the Yamaha TT-R110EY. This model is the result of Yamaha's vast experience in the production of fine sporting, touring, and pacesetting racing machines. It represents the high degree of craftsmanship and reliability that have made Yamaha a leader in these fields. [. . . ] In addition, do not use oils labeled "ENERGY CONSERVING II" or higher. Make sure that no foreign material enters the crankcase. 7 7-9 PERIODIC MAINTENANCE AND ADJUSTMENT EAU41635 1 Cleaning the air filter element The air filter element should be cleaned or replaced at the intervals specified in the periodic maintenance and lubrication chart. Clean or, if necessary, replace the air filter element more frequently if you are riding in unusually wet or dusty areas. Remove the air filter case cover by removing the screws. 1 2 2 1. Start the engine, and then let it idle for several minutes while checking it for oil leakage. If oil is leaking, immediately turn the engine off and check for the cause. Turn the engine off, and then check the oil level and correct it if necessary. 1 2 1. Clean the sponge material with solvent, and then squeeze the remaining solvent out. To avoid the risk of fire or explosion, do not use gasoline or solvents with a low flash point. [EWA10431] NOTICE: To avoid damaging the foam material, handle it gently and carefully, and do not twist or wring it. [ECA10511] 7-10 PERIODIC MAINTENANCE AND ADJUSTMENT mesh and the sponge material installed, otherwise the piston(s) and/or cylinder(s) may become excessively worn. [ECA15572] 1 1 6. Apply oil of the recommended type to the entire surface of the sponge material, and then squeeze the excess oil out. TIP The sponge material should be wet but not dripping. Recommended oil: Yamaha foam air filter oil or other quality foam air filter oil 1. Check the hoses at the bottom of the air filter case for accumulated dirt or water. NOTICE: Make sure that the mesh and the sponge material are properly seated in the air filter case. If dirt or water is visible, remove the hoses, clean them, and then reinstall them. EAU40421 Cleaning the spark arrester The spark arrester should be cleaned at the intervals specified in the periodic maintenance and lubrication chart. EWA10980 1 2 WARNING G G Always let the exhaust system cool prior to touching exhaust components. Bolt TIP Make sure to select a well-ventilated area free of combustible materials to clean the spark arrester. Remove the tailpipe by removing the bolts, and then pulling it out of the muffler. 2. Tap the tailpipe lightly, and then use a wire brush to remove any carbon deposits from the spark arrester portion of the tailpipe and inside of the tailpipe housing. 1 1. Insert the tailpipe into the muffler, and then install and tighten the bolts to the specified torque. Tightening torque: Tailpipe bolt: 10 Nm (1. 0 m·kgf, 7. 2 ft·lbf) EAU39930 EAU21362 Adjusting the carburetor The carburetor is an important part of the engine and requires very sophisticated adjustment. Therefore, most carburetor adjustments should be left to a Yamaha dealer, who has the necessary professional knowledge and experience. The adjustment described in the following section, however, may be serviced by the owner as part of routine maintenance. ECA10550 Adjusting the engine idling speed The engine idling speed must be checked and, if necessary, adjusted as follows at the intervals specified in the periodic maintenance and lubrication chart. [. . . ] YAMAHA MOTOR CORPORATION, USA Post Office Box 6555 Cypress, California 90630 10 10-4 CONSUMER INFORMATION 10 10-5 CONSUMER INFORMATION EAU26750 YAMAHA EXTENDED SERVICE (Y. E. S. ) Keep your Yamaha protected even after your warranty expires with genuine Yamaha Extended Service (Y. E. S. ). is designed and administered by Yamaha Motor Corporation to provide maximum owner satisfaction. You get uninterrupted factory-backed coverage for extra peace of mind. You choose the plan that's right for you: 12 months, 24 months, 36 months or, on certain models, even 48 months beyond your warranty period. [. . . ]